RZR 2016 xp4 turbo Overheating while idle. Is this normal?

Jhuerta

Jhuerta

Member
May 5, 2021
58
23
Hello All,

I'm curious. Does your RZR overheat while you are at idle? I have 2016 xp4 1000 turbo. Fyi I swapped out my radiator, thermostat, water pump. It was overheating before and I read that these models had a undersized radiator so I swapped it then I noticed it was still getting hot. I then swapped out thermosta then water pump. It was then that I realized the once I give it gas or rev it up the temp will drop to 150 or less. I didn't realize the water pump speed relied on engine speed. It works great while I'm rev it up so that's good I guess. Is this normal for anyone else? I will post pictures later.

Thank you 

 
I have a General that did the same thing, I had the dealer add a heater when purchased. It was a PITA to get all the air out of the system. There are a lot of suggested techniques to purge the cooling systems on the Polaris', I bled the air out a dozen times before I just parked it overnight with the nose as high as I could get it and pulled the radiator cap. Finally runs cool. 

 
raspadoo said:
I have a General that did the same thing, I had the dealer add a heater when purchased. It was a PITA to get all the air out of the system. There are a lot of suggested techniques to purge the cooling systems on the Polaris', I bled the air out a dozen times before I just parked it overnight with the nose as high as I could get it and pulled the radiator cap. Finally runs cool. 
Click to expand...
I had to do that with one of my past buggies, get the front up high and I could to purge the system and get air out.  Found out the hard way racing in an EPO, melted the motor.

 
It seems that I had air in the system.  I keep adding coolant after a few times of keeping it running.  Once it was full I was good. Thank you all. 

 
You must log in or register to reply here.
Back
Top